Eccentrics in Cycling

1958 Eccentric bottom bracket on Rene Herse Tandem – Daniel Rebour drawing.

Eccentric bottom bracket on 1977 Jack Taylor tandem

As part of restoring my 1977 Jack Taylor tandem, I needed to rebuild the eccentric bottom bracket and set it up correctly.  There’s been a bit of a learning curve, since I haven’t previously restored a vintage tandem.

The use of an eccentric appears to first date to the steam engine era, to optimize the efficiency of a rotating shaft.  And eccentric bicycle components have been around for over 100 years.  Yet, it can feel foreign, and daunting to work on a bike that features this technology.

What is an eccentric?  The official definition from Wikipedia is:  “in mechanical engineering, an eccentric is a circular disk (eccentric sheave) solidly fixed to a rotating axle with its centre offset from that of the axle (hence the word “eccentric”, out of the centre).”  The above photo depicts an eccentric pedal design introduced in 1903. 

Here’s a dual eccentric bottom bracket that can alter the gearing ratio at the crankset, also introduced in 1903.

Fred DeLong’s experimental fork dropouts

Fred Delong even spec’d a bike that had offset fork dropouts, to enable him to quickly change his bike’s rake and trail characteristics.  Although not technically an eccentric, this dropout design allowed him to choose when to optimize for trail and wheel flop, as shown in the table above.  A similar result could be achieved with an eccentric front hub.  Currently, eccentric hubs are limited in application to the rear where they are used to adjust chain tension on fixed gear bikes.

My Jack Taylor tandem features an eccentric bottom bracket that is similar in design to the 1958 model depicted at the top of this post. The threaded portion features a T.A. spindle and cups. There is a single hole drilled into the offset section.  Newer eccentric bottom brackets have multiple holes drilled, so that a pin spanner can be used to ease the adjustment process.  I can’t quite make out the lettering on this model – does it say “Rogers”?

I had wanted to rebuild the bottom bracket while it was off the bike – one of the benefits of this design.  However, when it came time to install the rebuilt BB back into the shell, the fit was very tight and needed to be accomplished with a mallet.  Not wanting to damage the cups or bearings, I disassembled it and then rebuilt it again once installed in the shell.  But, when I did so I ended up positioning the spindle toward the front rather than the rear of the bike.  That’s not what you want, since the whole idea of this design is to allow one to move the spindle toward the front as the timing chain stretches with wear.

I made this video showing how to adjust the eccentric bottom bracket on a model where only one hole is drilled. After loosening the bolts in the shell, and using an Allen wrench inserted into the hole and then leveraging that with a heavy duty screwdriver against the spindle, you can get the eccentric positioned where you want it to be.  It’s clear to me now that overhauling a tandem is much more involved than a typical restoration.  Still, it’s been fun to learn new techniques.  I’m looking forward to the rest of the process.

1977 Jack Taylor 650b Tandem

2014-09-21 001 031 1977 Jack Taylor Tandem

This is an unrestored Jack Taylor Touring Tandem, built for 650b wheels.  I had it shipped from England several years ago, but haven’t started work on it yet.

Even in its present state, it’s quite a pretty bike.  The frame color is silver, but with plenty of bright highlights that include red, yellow, green, blue and white.

The frame is built with Reynolds 531 tubing, and is fillet brazed.  It features a sloping top tube, giving 23″ and 21″ seat tube lengths for the front and rear positions.  Components include Maxi-car hubs, Campagnolo shifters and derailleurs, Weinmann 650b rims, Taylor Bros hammered fenders, front and rear constructeur racks, Mafac cantilever brakes, plus a front Maxi-car drum brake.

2014-09-21 001 010

Double front brakes – cantilevers + drum; Mafac levers and hoods in great shape.

2014-09-21 001 045

Jack Taylor transfers in really nice condition

2014-09-21 001 003

 

2014-09-21 001 007

Smooth brazing and a U.K. touring club sticker

2014-09-21 001 042

Simple cable stop,, elegantly brazed seat stays

2014-09-21 001 001

2014-09-21 001 008

Reynolds transfers in great shape

2014-09-21 001 009

Pin striping is still in really nice shape

2014-09-21 001 006

Maxi Car hubs, Campagnolo dropouts – with SN 7183

2014-09-19 001 001

TA crankset – there are two cranksets and each has at least one chain ring mounted on each side

2014-09-21 001 005

A type of presta valve I hadn’t seen before – there’s nothing under this cap – just an open valve – but I popped my presta fitting on anyway and pumped air into the tube.

2014-09-19 001 005

TA triple crankset with 50/40/28 rings

2014-09-21 001 041

Eccentric bottom bracket plus internal routing for the dynamo wiring

2014-09-21 001 026

Redundant chainring on the drive side front crank

2014-09-21 001 047

Campagnolo front derailleur

2014-09-21 001 049

Very cool Zefal pump

2014-09-21 001 046

Mafac cantilevers

2014-09-21 001 020

Campagnolo Rally rear derailleur, with Suntour Perfect 14/24 freewheel

2014-09-21 001 013

Color matched Milremo stem, Stronglight headset

2014-09-21 001 012

Dynamo and wiring

2014-09-19 001 006

Brooks saddles – a B-72 in the back and a B-17 in front

2014-09-21 001 022

2014-09-21 001 043

Some pitting in the top tube’s stoker section.

2014-09-21 001 039

Fork blades feature brazeons for the drum cable routing.

One of the things that surprised me about this bike was how similar it is in many ways to my 1973 Jack Taylor.  That bike is is also fillet brazed, and sports the exact same lighting system and rack design as this tandem.  In fact, its rear reflector is also broken, just like this.

2014-09-21 001 011

Another broken reflector

However, this reflector got broken in the shipping process.  One thing that I did was to have the bike shipped intact from England.  It boarded the Rio Mediera in Southampton, but was detained when it reached port in New York as suspected contraband.  The large container, built by Sheffpack, bore a suspicious resemblance to an arms shipment, and so it had to be x-rayed before it could continue its journey to the Port of Portland.  Consequently, the bike spent many weeks inside its shipping container, before it was finally literally broken open by port workers using hammers and tire irons.

However, it is safe and sound now, and with the fall and winter months looming ahead, this might be the perfect project to occupy the colder and wetter days ahead.